Winterizing Your RV’s Plumbing System
Winterizing Your RV’s Plumbing System avatar

Jayco

As much as we don’t like having to think about putting our RV away for the winter, it’s inevitable if you live in colder climates. That’s why we’re here with ways to properly prepare your RV for colder weather or storage, which is very important in most states and Canada. If an RV is not properly prepared for the winter months, it may cause water supply lines and the water heater to freeze. This post will give you some tips on how to best winterize your RV.

First off, your RV should be winterized at the end of the camping season or when the RV will be exposed to temperatures that will fall at or below 32°F (0°C).

 Depending on the type of RV you own, there are two methods of winterizing. Also, as always, we ask that you read, understand the instructions before beginning and follow the instructions as you go. Here are the two ways to winterize your RV depending on the type you have.

Air pressure

This method will utilize an air hose to blow excess water from the water lines.

1. Make sure all holding tanks are empty and drain valves OPEN.

2. Run the water pump until it is dry, this will take approximately 15-20 seconds.

3. OPEN all faucets and drains, and the toilet.

4. Using an air hose and adapter (customer supplied), blow air through the city water connection. Any remaining water will blow out in five to ten minutes.

5. Pour one cup of non-toxic RV antifreeze into all drain P-traps.

Demand or power plumbing system

It may be easier to winterize the RV with another person to assist you.

1. Level the RV and drain the fresh water plumbing system.

2. Replace the water filter cartridge with the clear plastic bypass hose (if so equipped).

3. Make sure the water heater 12-volt and 120-volt interior control switches are OFF.

4. Turn the water heater bypass valves to the BYPASS position.  For Jayco Motorized product:  Move the valves to the “Sanitize/Winterize Lines” position.

5. Make sure the “fresh tank drain” and “low point drains” are closed.  For Jayco Motorized product:  The low point drains must be closed for the antifreeze to siphon through the lines.

6. Insert the garden hose into a container of RV antifreeze solution (this quantity should be enough to winterize the RV); attach the other end to the City Water Fill.

7. Turn the water pump ON.

8. Open the hot water line on all the faucets (kitchen, lavatory, shower and outside shower) until RV antifreeze begins to flow continuously.

9. Close the faucet hot water lines and repeat with the cold water lines on all the faucets. Do not forget to run RV antifreeze through the toilet.

When you are done adding RV antifreeze

10. Remove the garden hose from the container of RV antifreeze.

11. To prevent staining, wipe the RV antifreeze out of the sinks, shower (or tub) and toilet using a soft, dry cloth.

As always, if you need assistance, please contact your local RV dealer.

 WARNING

Please note that repairs due to freezing are not covered under the terms of the Towable Limited Warranty. Also, automotive antifreeze (ethylene glycol) and windshield washer antifreeze (methanol) are poisonous. Never use these products in your fresh water system. These products are harmful and may be fatal if swallowed.

This entry was posted in Camping Trailers, Fifth Wheels, Jayco, Maintenance, Motorhomes, Product Information, RV, RVing, Toy Haulers, Travel Trailers. Bookmark the permalink. Both comments and trackbacks are currently closed.

3 Comments

  1. If you enjoy camping but take to an RV rather than a tent, then you know there’s work to be done at the end of the camping season. When you’re done camping for the year, and it’s time to leave your RV dormant for the winter, you need to take the appropriate steps to winterize an RV. Following such steps will help protect your RV’s appliances and water lines from freezing and, in turn, bursting, during the frigid winter months. To do this, you can either drain the water lines of water or add antifreeze to prevent lines from freezing.

  2. Scott R. Smith

    Every year I have problem’s pumping the anti-freeze through my 2006 Jayco 345BH. It always looses suction and it won’t pull the anti-freeze out of the bottle. I try holding the bottle above the city water inlet and that does not work. What I have to do is put a hand pump on the hose and pressurize it. I may have to do this more than once. This make a 15 minute job more than 1 or 2 hours. Any suggestions would be greatly appreciated. I have had this problem from the first year that we bought it. Thank you for any suggestions.

    • Hi Scott! Your local Jayco dealer should have some helpful tips to help you with this issue or you can always call our Customer Service department directly at 800-283-8267.

One Trackback

  1. [...] Stories, insights and tips shared by the Jayco Family. Skip to content Contributors « Winterizing Your RV’s Plumbing System By Jayco | Published: September 28, [...]